Posted by mazemeister on June 29, 2014 at 15:34:16 from (173.3.255.19):
In Reply to: Butchering Chickens posted by John in La on June 29, 2014 at 09:44:34:
you can do it yourself. get a big pot and a propane burner like in the pic. for just 50 birds, i wouldn't bother with the drill powered plucker; your hands should be just as good.
for killing- get 1 or more killing cones. usually galvanized- with a hole to let the head out the bottom. the cones are important so they don't flap the wings, potentially breaking one. one cut with a sharp knife is all it takes- some technique that comes through experience is essential there.
for scalding, a pot, burner, and thermometer, wooden stick to agitate. i think the temp/time depends in part on how the birds are raised- how many feathers, etc. but i find that 148-150 F, 30-40 sec is a good place to start. if you tear the skin trying to pluck, the water's too hot.hang the bird with a rope around one foot, and "rub" the feathers off. except for tail and wing feathers, they should all just slip right off.
takes time, and helps to have some helpers, but very doable.
what works well is to use a clean rubbermaid stock tank or similar with a hose running to overflow for the initial chill- after plucking. then, after they're all dead and plucked, do the evisceration and into the fridge.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Hydraulics - Cylinder Anatomy - by Curtis von Fange. Let’s make one more addition to our series on hydraulics. I’ve noticed a few questions in the comment section that could pertain to hydraulic cylinders so I thought we could take a short look at this real workhorse of the circuit. Cylinders are the reason for the hydraulic circuit. They take the fluid power delivered from the pump and magically change it into mechanical power. There are many types of cylinders that one might run across on a farm scenario. Each one could take a chapter in
... [Read Article]
Latest Ad:
1964 I-H 140 tractor with cultivators and sidedresser. Starts and runs good. Asking 2650. CALL RON AT 502-319-1952
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
