Posted by SWVA Zetor on March 28, 2015 at 14:46:24 from (67.237.189.100):
I get to the tractor and start it for the first time of the day. This problem happens no matter what time of day or season it is. (6 month going on problem) The tractor starts just fine two to three cranks and fires right up. I let it sit and warm up for a min or two depending on how cold it is. And it gets up to operating temp no problem and stays there. I can run it for 24 minutes fast slow loading unloading bales no issues when it starts to slowly but surly die over a coarse of 10-20 seconds. If I wait 5-10mins the tractor will start again but will take a lot of crank time and runs rough as a cob for a minute or two then will die again with in 10 mins and the process can or will start all over again depending on what I need to get done. To me it’s like someone has just turned the fuel off but this is where I can’t understand what the problem might be. Because I have replaced most of the fuel system over the past 6 years. I will give you a breakdown of what I have tried and parts that I have replaced.
The tractor has 2800 hrs on it 2008 I replaced the injectors and metal lines alone with the rubber lines 2009 I replaced the injector pump, or had it rebuilt…long story but symptoms are not the same not as what I had before. 2015 I replaced the fuel lift pump I thought that was my problem this time. I also ran it with out the fuel cap on to check to see if it was getting vapor locked.
I also do regular matinees on the fuel system change the filter ect. And have checked all rubber fuel lines for cracks and leaks and none to been found.
If any one has had this problem before and has fixed it I would love to know what their solution is.
Upload one or more videos to your post. Photo filesizes should be less than 300K and Videos, less than 2MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - A Lifetime of Farm Machinery - by Joe Michaels. I am a mechanical engineer by profession, specializing in powerplant work. I worked as a machinist and engine erector, with time spent overseas. I have always had a love for machinery, and an appreciation for farming and farm machinery. I was born and raised in Brooklyn, New York. Not a place one would associate with farms or farm machinery. I credit my parents for instilling a lot of good values, a respect for learning, a knowledge of various skills and a little knowledge of farming in me, amo
... [Read Article]
Latest Ad:
1964 I-H 140 tractor with cultivators and sidedresser. Starts and runs good. Asking 2650. CALL RON AT 502-319-1952
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
