Posted by Janicholson on August 07, 2021 at 06:51:41 from (24.240.46.228):
In Reply to: Lead acid battery posted by Dave BN on August 07, 2021 at 06:26:05:
The sulfuric acid in the electrolyte is the source of the problem, but the chemical reaction that is the actual problem is the creation of lead sulfate from the lead of the plates and the sulfur from the acid. This white semi-crystalline solid is electrically conductive and shorts out the the positive and negative plates across the ends of the bundles, or through deteriorating separators. The battery when fully charged has one plate of sponge lead sulfate, and the other of sponge lead. The discharged battery has both plates sulfated to near identical. The acid in the electrolyte is now nearly gone, and in fact the remaining acid is so weak that a dead battery can freeze. The battery rebuilders are few and far between today due to regulation, and the hit miss success rate of taking them apart, cleaning and chemical restructuring the plates to take a charge again. Sealed plastic batteries have made that even harder. So it will do no good to drain the acid, and it will be a nasty safety issue as well. I have repaired a cracked case (physical damage) with the acid removed from that cell, but it cost a pair of jeans and 3 hours. Jim
Upload one or more videos to your post. Photo and video filesizes should be less than 5MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Tractor Profile: Farmall M - by Staff. H so that mountable implements were interchaneable. The Farmall M was most popular with large-acreage row-crop farmers. It was powered by either a high-compression gas engine or a distillate version with lower compression. Options included the Lift-All hydraulic system, a belt pulley, PTO, rubber tires, starter, lights and a swinging drawbar. It could be ordered in the high-crop, wide-front or tricycle configurations. The high-crop version was called a Model MV.
... [Read Article]
Latest Ad:
1964 I-H 140 tractor with cultivators and sidedresser. Starts and runs good. Asking 2650. CALL RON AT 502-319-1952
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.