For all those who have complained about their batteries draining after tractor sits un-used for a week or so, the content of Mr. J.A. Nicholson's post over on the Farmall board, may explain the problem. I have measured that 'standby' drain on several 3-wire set-ups. NOTE: both 3 wire and 1 wire always have a continuous drain whether ignition is on or off!
Jim says, "The internal VR in some of the one wire systems draws about 200ma (if measured across an open battery terminal) others draw more like 500ma or more."
Whereas, my measurements for 3-wire show 0.75ma.
Best case then is 200/0.75=267X worse AND worst case is 500/0.75=667X worse drain.
Knowing that you can't extract every last amp-hour out of a battery, for sake of this discussion let us assume that we can. Real life results won't be this good, by some margin. Further more, if you did extract every last A-H, then there would be zero left to operate a starter.
Start with a 75amp-hour full charged battery. Apply the 3-wire 0.75ma drain.
75A-H divided by 0.75ma=100,000 hours. Divided by 24hr/day, yields 4,167 days (or 11 years). We all know that most batteries sitting on a shelf connected to nothing won't last that long. So what this says to me is that the 0.75ma drain is reasonably insignificant.
BUT, look what happens when we apply the 267X worse or the 667X worse 1-wire 'standby' drains: the 4,167 days divided by 267=15 days.***
Even worse, 4,167 divided by 667=6 days.*****
I have personally measured the 'standby' drain on a 1-wire set-up, D22ac-1 internal reg, and it was 1.8mA, but have no other reason to doubt Mr. Nicholson. So, it seems reasonable then that a dead battery after a few days might very well be related to a 1-wire alternator, if his numbers hold.. Measured D22AC-1, 1.8mA drain, or 2.4 X the GM 3 wire 0.75Ma drain..4.6 years vs 11 years
Rather than speculation or even testimonials, such as 'mine doesn't discharge that fast', I would like to see a good hand full of 'standby' drain current measurements made & posted by anyone able to perform same.
No doubt, all 1-wire regulators are not born equal.
It could be that when & where those high 'standby' drains are encountered, that the regulator is just plain faulty and really has nothing to do with 1-wire vs 3-wire. However, speculation, testimonials are not the answer, just some real current measurements.
I hope we see some measurements!
One final note, Modern vehicles have computers and some have a 25mA drain all the time, but even those calculate out to 0.75/25 X 11 = 4 months.
Upload one or more videos to your post. Photo and video filesizes should be less than 8MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Restoration Story: Fordson Major - by Anthony West. George bought his Fordson Major from a an implement sale about 18 years ago for £200.00 (UK). There is no known history regarding its origins or what service it had done, but the following work was undertaken alone to bring it up to show standard. From the engine number, it was found that this Major was produced late 1946. It was almost complete but had various parts that would definitely need replacing.
... [Read Article]
Latest Ad:
1964 I-H 140 tractor with cultivators and sidedresser. Starts and runs good. Asking 2650. CALL RON AT 502-319-1952
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
