Tractor Talk Discussion Board |
Re: Power steering making noise
[ Expand ] [ View Follow Ups ] [ Post Followup ] [ Return to Forum ]
Posted by Patrol on February 08, 2004 at 01:10:46 from (81.182.143.118):
In Reply to: Power steering making noise posted by abane on February 06, 2004 at 08:45:57:
Warm up the unit. Try to eliminate all leakages. Check fluid reservoir for any trace of foaming up. If so, check suction circuit, retight clamps, check tubes, lines, pipes. Check pump front and rear cover, the front seal of shaft, pipe connections with engine stopped for any leakages. Check the suction circiut from reservoir up to the pump. Cold and dense fluid may sighltly open the pressure regulator and the bypassing oil around the valve generates noise. After warming up place a suitalbe pressure gauge with "T" connector into the pressure line to the steering steering cylinder and check max. operating pressure steering the wheel to its limit to left and rights. Keep steering wheel in its full end position while you may check the max. pressure. In case noise still exists: Check pressure regulator valve spool for scores, crackes and traces of jamming. Check spool housing, spring, eventulally sims under the spring. Adjust as necessary. If operating pressure can not be obtained, disassemble the pump, check and overhaul. KEEP YOUR WORKING AREA AS CLEAN AS POSSIBLE!
Follow Ups:
Home
| Forums
Today's Featured Article -
A Lifetime of Farm Machinery - by Joe Michaels. I am a mechanical engineer by profession, specializing in powerplant work. I worked as a machinist and engine erector, with time spent overseas. I have always had a love for machinery, and an appreciation for farming and farm machinery. I was born and raised in Brooklyn, New York. Not a place one would associate with farms or farm machinery. I credit my parents for instilling a lot of good values, a respect for learning, a knowledge of various skills and a little knowledge of farming in me, amo
... [Read Article]
Latest Ad:
1964 I-H 140 tractor with cultivators and sidedresser. Starts and runs good. Asking 2650. CALL RON AT 502-319-1952
[More Ads]
Copyright © 1997-2024 Yesterday's Tractor Co. All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V. Yesterday's Tractors - Antique Tractor HeadquartersWebsite Accessibility Policy |
|