Posted by JDseller on February 22, 2011 at 20:23:04 from (208.126.196.144):
In Reply to: Massey 583 posted by JBMac on February 22, 2011 at 17:44:24:
If it will not disengage after slipping you have damaged the clutch disk or pressure plate. The clutch disk maybe warped or the facings have stacked up. The pressure plate can have broken a spring or diaphragm and is not fully releasing. There is no way to tell without splitting the tractor.
When clutch plates wear it reduces the free travel clearance. When the free travel is gone then the clutch slips even without you having your foot on it. Your PTO clutch may have needed adjusted sooner than you think because of your heavy usage. The ground drive half may have been fine but the PTO half needed adjusted. I am not sure on MF583 if you can adjust the PTO clutch on a live PTO setup from the outside. Many two stage or live PTOs are set by setting the pressure plate fingers during assembly and can"t be adjusted independent of each other after that. A 7 foot BUSH hog on a 73 PTO hp tractor in heavy right away mowing is at the low end of the range.
This issue shows the weakness of a two stage dry PTO clutch. For real heavy duty continuous use a independent oil bathed clutch will have many fewer issues.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Restoration Story: Fordson Major - by Anthony West. George bought his Fordson Major from a an implement sale about 18 years ago for £200.00 (UK). There is no known history regarding its origins or what service it had done, but the following work was undertaken alone to bring it up to show standard. From the engine number, it was found that this Major was produced late 1946. It was almost complete but had various parts that would definitely need replacing.
... [Read Article]
Latest Ad:
1964 I-H 140 tractor with cultivators and sidedresser. Starts and runs good. Asking 2650. CALL RON AT 502-319-1952
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
